Analysis: Why evolution was no option for McLaren

McLaren may have raised some eyebrows with the step change in its car design for this season, but technical chiefs are adamant it was an essential move if it is to gun for Formula 1 title glory this year.

Analysis: Why evolution was no option for McLaren

McLaren may have raised some eyebrows with the step change in its car design for this season, but technical chiefs are adamant it was an essential move if it is to gun for Formula 1 title glory this year.

With the rules not changing dramatically for 2013, and teams already devoting much resource to the radical 2014 overhaul, it had been widely expected that the new cars would be mere evolutions of last year's designs.

McLaren has gone much further than that, however. It was reworked its concept in a wide range of areas, including switching to pull-rod suspension, increasing the height of its chassis so it now needs a 'vanity' panel' for a stepped nose, and being ultra-aggressive with the bodywork around the rear.

Although such work may be a bold move with 2014 on the horizon, the team has said that such an effort was vital if the team was to be able to keep up a good enough development rate throughout the forthcoming campaign.

When asked by AUTOSPORT about the thinking behind such an aggressive push with its car, McLaren engineering director Tim Goss said that there was a fear last year's MP4-27 concept was reaching a development ceiling.

"We looked at our performance during last season, in the stages where we were laying down the foundations of this car, and looked at where we thought we would get to in terms of our development rate if we just kept continuing with developing the same car," he said. "We realised we actually needed to make a larger step.

"So in defining the architecture of this car, the philosophy was very much to give ourselves the scope to further exploit the area of the cars that we knew would generate performance.

"We understand how to get the most out of these rules, and we demonstrated that last season under these rules with the quickest car at the beginning of the year and the end of the year.

"But, we decided that we need to give ourselves a bit more freedom and, as a result of that, we have reworked the car from front to back. That has allowed us that bit more freedom to push the areas of the car that we know respond."

Pull-rod front suspension

One of the boldest departures for McLaren is in switching from a push-rod to pull-rod layout with its front suspension, a route that Ferrari went down last season.

Goss insisted that its change was not simply the result of it copying Ferrari's lead, but of doing a lot of work into evaluating the benefits and drawbacks of such a design.

"What convinced us was actually a lot of research," he said. "When you see something new on a car, you always think, why have they done that?

"In F1, it is possible to copy someone else's concept, but invariably they don't work. What you have to do is get a fundamental understanding of why.

"So we looked at it and initially we thought exactly that - why? But after some time and some work we understood how it could benefit our car and certainly what we are trying to achieve with the car.

"We found benefits in terms of aerodynamics, which overcome the kinematic and structural negatives of doing more extreme anhedral suspension."

Exhaust concept

One area where McLaren has stuck to its guns, however, is in its exhaust concept, which is a different solution to the Red Bull style.

This year, McLaren has pushed things much further, dramatically cutting away the bodywork at the rear of the car to try and optimise airflow for both car performance and exhausts.

"It is playing the tunes on the aerodynamics," said Goss. "While trying to achieve one thing with the exhaust, you have to make sure when the exhaust gases are not flowing that the rear end of the car is still performing properly.

"So we have pushed things further. That is our philosophy on this car - to take the things where we know the car responds, push them further and make them more extreme. For us, it was a natural evolution of last year."

McLaren MP4-28 - full coverage:

McLaren unveils new MP4-28 F1 car
Lowe staying for 2013, McLaren insists
MP4-28 unveiling gallery
Perez hails 2013 preparations
McLaren won't race passive double DRS

shares
comments
Marussia reveals MR02 launch date
Previous article

Marussia reveals MR02 launch date

Next article

Ferrari presents the F138 Formula 1 car in Maranello

Ferrari presents the F138 Formula 1 car in Maranello
The inconvenient truth about F1’s ‘American driver’ dream Plus

The inconvenient truth about F1’s ‘American driver’ dream

OPINION: The Formula 1 grid's wait for a new American driver looks set to continue into 2023 as the few remaining places up for grabs - most notably at McLaren - look set to go elsewhere. This is despite the Woking outfit giving tests to IndyCar aces recently, showing that the Stateside single-seater series still has some way to go to being seen as a viable feeder option for F1

How a bad car creates the ultimate engineering challenge Plus

How a bad car creates the ultimate engineering challenge

While creating a car that is woefully off the pace is a nightmare scenario for any team, it inadvertently generates the test any engineering department would relish: to turn it into a winner. As Mercedes takes on that challenge in Formula 1 this season, McLaren’s former head of vehicle engineering reveals how the team pulled of the feat in 2009 with Lewis Hamilton

Formula 1
Aug 15, 2022
The under-fire F1 driver fighting for his future Plus

The under-fire F1 driver fighting for his future

Personable, articulate 
and devoid of the usual
 racing driver airs and graces,
 Nicholas Latifi is the last Formula 1 driver you’d expect to receive death threats, but such was the toxic legacy of his part in last year’s explosive season finale. And now, as ALEX KALINAUCKAS explains, he faces a battle to keep his place on the F1 grid…

Formula 1
Aug 13, 2022
The strange tyre travails faced by F1’s past heroes Plus

The strange tyre travails faced by F1’s past heroes

Modern grand prix drivers like to think the tyres they work with are unusually difficult and temperamental. But, says  MAURICE HAMILTON, their predecessors faced many of the same challenges – and some even stranger…

Formula 1
Aug 12, 2022
The returning fan car revolution that could suit F1 Plus

The returning fan car revolution that could suit F1

Gordon Murray's Brabham BT46B 'fan car' was Formula 1 engineering at perhaps its most outlandish. Now fan technology has been successfully utilised on the McMurtry Speirling at the Goodwood Festival of Speed, could it be adopted by grand prix racing once again?

Formula 1
Aug 11, 2022
Hamilton's first experience of turning silver into gold Plus

Hamilton's first experience of turning silver into gold

The seven-time Formula 1 world champion has been lumbered with a duff car before the 2022 Mercedes. Back in 2009, McLaren’s alchemists transformed the disastrous MP4-24 into a winning car with Lewis Hamilton at the wheel. And now it’s happening again at his current team, but can the rate of progress be matched this year?

Formula 1
Aug 11, 2022
Why few could blame Leclerc for following the example of Hamilton’s exit bombshell Plus

Why few could blame Leclerc for following the example of Hamilton’s exit bombshell

OPINION: Ferrari's numerous strategy blunders, as well as some of his own mistakes, have cost Charles Leclerc dearly in the 2022 Formula 1 title battle in the first half of the season. Though he is locked into a deal with Ferrari, few could blame Leclerc if he ultimately wanted to look elsewhere - just as Lewis Hamilton did with McLaren 10 years prior

Formula 1
Aug 9, 2022
The other McLaren exile hoping to follow Perez's path to a top F1 seat Plus

The other McLaren exile hoping to follow Perez's path to a top F1 seat

After being ditched by McLaren earlier in his F1 career Sergio Perez fought his way back into a seat with a leading team. BEN EDWARDS thinks the same could be happening to another member of the current grid

Formula 1
Aug 8, 2022