Toyota tests WEC car on three wheels to simulate Le Mans issues

Toyota has tested its TS050 HYBRID on three wheels as it continues to simulate random problems in its bid to break its victory duck at the Le Mans 24 Hours

Toyota tests WEC car on three wheels to simulate Le Mans issues

One of Toyota's 2018/19 World Endurance Championship challengers was sent out of the pits with a front wheel missing during an endurance simulation at the Aragon circuit last month so that the team could learn how to deal with the situation should it arise in the race this June.

Toyota Motorsport GmbH technical director Pascal Vasselon said: "In Aragon we have done one lap on three wheels and asked the team to bring back the car.

"We have understood the additional problems you can get with the front differential, for example."

Vasselon explained that the team had already completed the same exercise, with a rear wheel removed at a previous test.

Toyota has been exploring an array of problems during its endurance simulations in order to be as prepared as possible for the kind of exceptional circumstances that deprived it of victory at Le Mans in 2014, '16 and '17.

"We did not need as much mileage as the year before, so we have sacrificed mileage to train the team to handle fake problems," Vasselon said.

"The target was to train the team to handle the unexpected and it worked quite well.

"The exceptional now is not so exceptional, but obviously the adrenalin and stress you have during the race will trigger additional difficulties."

As many as "20 to 25" different issues have been simulated by Toyota so far this year, according to Vasselon.

These have included surprising the driver by ceasing all radio communication on circuit and simulating driveshaft failures.

Vasselon also revealed that the turbo issue that cost Toyota Le Mans victory in 2016 with six minutes to go would not have been an issue one year later.

He explained that the problem was precipitated by the late decision to develop a turbocharged engine for the 2016 WEC.

"When we came to Le Mans the engine was working very well when everything was going well, but when we lost the pipe [from the turbo to the intercooler] the systems were not able to handle that and we lost completely the power," he said.

"Now if this happens, the system will immediately use the other bank of cylinders and we will do a lap of four minutes rather than 3m20s.

"It is a good example of a problem whose magnitude depends on how well you are prepared."

Toyota's recent Le Mans near-misses

2014 A slim but stable advantage over Audi during the night is undone when an FIA sensor short circuits and strands race leader Kazuki Nakajima out on track.

The Toyota had been scheduled to stop at the end of the lap to have the issue fixed.

2016 Toyota is on course for victory after a thrilling battle with Porsche until Nakajima loses power early on the penultimate lap when a connection on an airline between the turbo and intercooler fractures.

He is able to complete the race, but the car is excluded because its last lap is too slow.

2017 Toyota loses its best chance for victory in the night when Kamui Kobayashi is waved through a red light at the end of the pits by someone he thinks is a marshal, but turns out to be another driver.

The Japanese driver is told to stop and then burns out the clutch trying to get going.

shares
comments
Sarrazin: Toyota played games with privateer LMP1 rivals in WEC test

Previous article

Sarrazin: Toyota played games with privateer LMP1 rivals in WEC test

Next article

ByKolles WEC squad could expand to run two LMP1 cars after Le Mans

ByKolles WEC squad could expand to run two LMP1 cars after Le Mans
Load comments

About this article

Series WEC
Teams Toyota Racing
Author Gary Watkins
The philosophical problems the WEC's new Hypercar class is already facing Plus

The philosophical problems the WEC's new Hypercar class is already facing

OPINION: Most of the column inches after the World Endurance Championship's opener were centred around the relative pace of the Hypercar class and the LMP2s, but there's another question that needs addressing in order for the new division to have a successful future

WEC
May 7, 2021
How stumbling Toyota drew first blood in the WEC's new era Plus

How stumbling Toyota drew first blood in the WEC's new era

Amid concerns that the new Hypercar class would be upstaged on debut by the spec LMP2 machines at Spa, Toyota delivered the pole and victory that the vast majority of observers expected. But neither car had a clean run, which gave the grandfathered Alpine LMP1 an unexpected shot at glory

WEC
May 4, 2021
Seven things to watch in the 2021 World Endurance Championship Plus

Seven things to watch in the 2021 World Endurance Championship

Beyond the slender grid of headline-grabbing hypercars, there are numerous subplots and changes to look out for in the new season of the WEC, which gets underway at Spa this weekend. Here's the seven key things you need to know about

WEC
Apr 30, 2021
What to expect from sportscar racing's bold new Hypercar era Plus

What to expect from sportscar racing's bold new Hypercar era

A slim field of three cars will be entered in the Hypercar class for the first round of the World Endurance Championship's post-LMP1 age. But there are plenty of reasons for optimism with the new wave of manufacturer entries and competing class philosophies just around the corner

WEC
Apr 29, 2021
How Aston Martin Racing scaled new heights in the Prodrive era Plus

How Aston Martin Racing scaled new heights in the Prodrive era

The 2021 World Endurance Championship kicks off at Spa this weekend, but for the first time since its 2012 inception there will be no works Aston Martins in the GTE-Pro class. As its new era in Formula 1 begins, Aston leaves behind a legacy of success courtesy of its Prodrive-run factory programme that was a hit from the word go in 2005

WEC
Apr 27, 2021
How 'Brilliant' Bob Wollek lived up to his nickname Plus

How 'Brilliant' Bob Wollek lived up to his nickname

Sportscar racing lost one of it's greatest talents 20 years ago today when Bob Wollek was knocked from his bicycle prior to the Sebring 12 Hours. The enigmatic Frenchman never won the Le Mans 24 Hours, but many still remember today why 'Brilliant Bob' became a legend

WEC
Mar 16, 2021
Top 10 moments of an underrated British great Plus

Top 10 moments of an underrated British great

Brian Redman was one of the best sportscar drivers of the 1960s and 1970s, as well as a three-time champion on the fearsome American Formula 5000 scene. To celebrate his 84th birthday Autosport contacted him about his best races – and he decided to write the piece himself…

WEC
Mar 9, 2021
How an endurance racing boom could help one of LMP2's top teams Plus

How an endurance racing boom could help one of LMP2's top teams

The G-Drive squad has been a mainstay of endurance racing in recent years, and has linked up with Russian manufacturer Aurus in recent years to promote its brand. With a change of rules in endurance racing's top tables, the team could be well-placed to take advantage of a potential boom...

WEC
Mar 7, 2021