How Porsche turned its WEC LMP1 winner into an F1 beater

This week, Porsche managed to shatter the unofficial Formula 1 lap record around Spa-Francorchamps with an upgraded version of its 919 Hybrid

How Porsche turned its WEC LMP1 winner into an F1 beater

It's rare that we get to see what racing cars are capable of once their programmes come to an end, but Porsche has done something incredibly special by creating the 919 Evo tribute, a machine that totally ignores the technical regulations that held back the potential of its World Endurance Championship-winning counterpart.

The lap record it beat around the Belgian Grand Prix venue was relatively fresh too, having been recorded last year by Lewis Hamilton in his Mercedes W08 - a car that also had a serious increase in downforce thanks to the new Formula 1 regulations introduced in 2017.

Neel Jani's target time to beat was a 1m42.553s - a feat that seems even more implausible if we consider the standard car managed a 1m54.097s in WEC qualifying in 2017. But Jani smashed that time, recording a 1m41.770s that was 0.783 seconds quicker than Hamilton's pole lap and more than 12 seconds faster than the WEC pole lap.

But how did the car achieve that time?

Firstly, it's worth noting that as part of the project it was decided that the 919's powertrain would remain untouched, as the Evo continued to be powered by Porsche's turbocharged two-litre V4 engine with two energy recovery systems.

But without the limitations imposed by WEC's LMP1 regulations, the development team was free to ignore fuel flow constraints and upped the flow rate to allow the Evo's engine to deliver 720bhp in its own right (up from 500bhp) while still using regular race fuel.

As part of the efficiency matrix that shackled the 919 Hybrid on its 2017 pole lap, the driver only had 6.37 megajoules of energy at his disposal. But for this run, Porsche exploited the energy recovery system's full potential, gaining another 40hp as it utilised 8.49MJ of energy.

Combined, that meant the powertrain's output increased from an already-healthy 900bhp to 1160bhp - an astonishing achievement given it was done with the same equipment and fuel, albeit with a number of software updates.

Increasing the car's output by a third would be useless without being able to control it, so it's no surprise that under the car's frame numerous changes had to be made too. The Evo utlises a four-wheel brake-by-wire system, giving the driver more control in yaw. New front and rear suspension wishbones had to be crafted in order to endure the higher loads that the car would be put under.

The Pitch Link System used to control the car's attitude was also updated and includes an actively controlled lockout system, which was not possible under WEC regulations. All of these changes required the power steering to be adapted, too, so Jani could exploit the 919's newfound agility.

All of this would have been for nought had it not been transferrable to the tarmac, and Michelin developed new compounds to provide the necessary grip.

A motorsport engineer's biggest enemy is weight. As such, the 919 went on a serious diet, shedding all non-essential components. The Evo weighs 39kg less than its sibling, with the air conditioning, windscreen wiper, several sensors, electronic devices from race control, lights systems and the pneumatic jack system all discarded.

Aerodynamics are a huge differentiator in top level motorsport, and the Evo's aero package was a significant upgrade on its WEC version - with drag reduction systems (DRS) added to the front and rear and a totally revamped aero solution resulting in 53% more downforce and an increase in efficiency of 66%.

Of course, these gains are predominantly down to the fact that aerodynamicists threw the technical regulations in the bin, but there are also developments that didn't see the light of day because Porsche didn't compete in WEC this year that have made their way onto the car.

The front of the 919 has been totally reworked and, with the headlight assemblies considered total dead weight, designers could streamline the fenders and dramatically reduce the size of regulatory holes introduced by rulemakers to reduce the chance of takeoff when the car goes sideways (red arrows).

A major driving force in the car's drag reduction and improved downforce comes from the hydraulically-operated DRS, which changes the angle of the front splitter's trailing edge. It's a solution that's twinned with a much larger and more rearward-cited rear wing assembly, that also features DRS - improving balance, reducing drag and increasing downforce.

The floor was also reworked, optimising flow towards a revised diffuser that takes advantage of fixed-height side skirts that help to seal the edges of the floor and increase ground effect.

The slatted rear assembly in the rear wheelpods have been discarded too, as they were more about fulfilling regulatory criteria than enhancing performance. Along with this, the team tidied up the entire rear end, while the side skirt was modified further during the course of three-day test, undoubtedly as a result of needing to improve the aerodynamic behaviour of the car (red arrows).

You might argue that the Evo is a pointless exercise, but it allowed engineers that worked on the 919 for more than four years to loosen the reins and at least take a glimpse at what is possible.

That said, the Evo is still barely scratching the surface of what would be attainable, with the limitation of time, funding and resources holding back its absolute potential. Perhaps one day management will see fit to loosen the purse strings even further.

shares
comments
ByKolles WEC squad could expand to run two LMP1 cars after Le Mans

Previous article

ByKolles WEC squad could expand to run two LMP1 cars after Le Mans

Next article

Why Sebring round should be the catalyst for more varied WEC events

Why Sebring round should be the catalyst for more varied WEC events
Load comments

About this article

Series WEC
Teams Porsche Team
Author Matt Somerfield
The philosophical problems the WEC's new Hypercar class is already facing Plus

The philosophical problems the WEC's new Hypercar class is already facing

OPINION: Most of the column inches after the World Endurance Championship's opener were centred around the relative pace of the Hypercar class and the LMP2s, but there's another question that needs addressing in order for the new division to have a successful future

WEC
May 7, 2021
How stumbling Toyota drew first blood in the WEC's new era Plus

How stumbling Toyota drew first blood in the WEC's new era

Amid concerns that the new Hypercar class would be upstaged on debut by the spec LMP2 machines at Spa, Toyota delivered the pole and victory that the vast majority of observers expected. But neither car had a clean run, which gave the grandfathered Alpine LMP1 an unexpected shot at glory

WEC
May 4, 2021
Seven things to watch in the 2021 World Endurance Championship Plus

Seven things to watch in the 2021 World Endurance Championship

Beyond the slender grid of headline-grabbing hypercars, there are numerous subplots and changes to look out for in the new season of the WEC, which gets underway at Spa this weekend. Here's the seven key things you need to know about

WEC
Apr 30, 2021
What to expect from sportscar racing's bold new Hypercar era Plus

What to expect from sportscar racing's bold new Hypercar era

A slim field of three cars will be entered in the Hypercar class for the first round of the World Endurance Championship's post-LMP1 age. But there are plenty of reasons for optimism with the new wave of manufacturer entries and competing class philosophies just around the corner

WEC
Apr 29, 2021
How Aston Martin Racing scaled new heights in the Prodrive era Plus

How Aston Martin Racing scaled new heights in the Prodrive era

The 2021 World Endurance Championship kicks off at Spa this weekend, but for the first time since its 2012 inception there will be no works Aston Martins in the GTE-Pro class. As its new era in Formula 1 begins, Aston leaves behind a legacy of success courtesy of its Prodrive-run factory programme that was a hit from the word go in 2005

WEC
Apr 27, 2021
How 'Brilliant' Bob Wollek lived up to his nickname Plus

How 'Brilliant' Bob Wollek lived up to his nickname

Sportscar racing lost one of it's greatest talents 20 years ago today when Bob Wollek was knocked from his bicycle prior to the Sebring 12 Hours. The enigmatic Frenchman never won the Le Mans 24 Hours, but many still remember today why 'Brilliant Bob' became a legend

WEC
Mar 16, 2021
Top 10 moments of an underrated British great Plus

Top 10 moments of an underrated British great

Brian Redman was one of the best sportscar drivers of the 1960s and 1970s, as well as a three-time champion on the fearsome American Formula 5000 scene. To celebrate his 84th birthday Autosport contacted him about his best races – and he decided to write the piece himself…

WEC
Mar 9, 2021
How an endurance racing boom could help one of LMP2's top teams Plus

How an endurance racing boom could help one of LMP2's top teams

The G-Drive squad has been a mainstay of endurance racing in recent years, and has linked up with Russian manufacturer Aurus in recent years to promote its brand. With a change of rules in endurance racing's top tables, the team could be well-placed to take advantage of a potential boom...

WEC
Mar 7, 2021