Giorgio Piola's F1 technical analysis
Topic

Giorgio Piola's F1 technical analysis

The Red Bull design that avoided a flexi-wing protest

Formula 1 had arrived at the Azerbaijan Grand Prix braced for a showdown over the flexi-wing saga.

The Red Bull design that avoided a flexi-wing protest

With new tougher FIA pull-back tests not due to come into force until the French GP, the race in Baku was the last chance for outfits to get away with their more bendy rear wings.

That prospect annoyed teams like Mercedes and McLaren, and the threat of a protest remained if outfits went too far in what they did in Baku.

It was perhaps the threat of a formal complaint, and the inherent risk of a disqualification if the FIA stewards sided with a protester, that perhaps meant the issue never raised its head.

For while Red Bull had been centre of attention after the Spanish Grand Prix with its flexi-wing antics, it elected to run in Baku with a new interim spoon-shaped wing that acted in a much more normal manner and helped steer clear of any controversy.

This Red Bull design features a mainplane with a deeper central section to create the necessary downforce, while the outer channels are shallower in order that the resultant tip vortex created by the airflow’s collision with the endplate is lessened.

To feed into this, Red Bull also made changes to its endplate design, returning to a plainer design in order that it would be less aggressive on the airflow.

 

Photo by: Giorgio Piola

The stepped cut-out in the upper corner gave way to a more conventional design, whilst the upwash strikes and louvres hanging strakes were also removed and simplified (see Monaco inset for the usual 2021 design).

The wing, shown in the illustration, also has a section cut away on the trailing edge of the upper flap.

However, while that version of the wing made an appearance, it didn’t actually find its way onto the car in a competitive session in Baku but will likely return at the Belgian GP.

The team opted to run without a Gurney flap on the trailing edge of the wing though, sacrificing some balance for straightline speed (see Spa 2020 inset for comparison with a Gurney attached).

Driver split tactics

It’s always fascinating to see how team-mates respond to the prevailing challenges too, with each driver making set-up and aero changes that suit their own requirements.

In the case of Sergio Perez and Max Verstappen, there was an almost imperceptible difference between their rear wings, as the Dutchman opted for the trailing edge of the wing to be trimmed slightly to reduce drag further still.

Mercedes also opted for different rear wing configurations on its cars at Baku, albeit a totally different concept rather than the subtle difference seen at championship rivals, Red Bull.

The two different wing specifications used by Lewis Hamilton and Valtteri Bottas

The two different wing specifications used by Lewis Hamilton and Valtteri Bottas

Photo by: Giorgio Piola

After trawling through the data from Friday’s free practice sessions, where the team had struggled for pace, Lewis Hamilton opted for the lower downforce arrangement, with just a single support pillar connected to the DRS actuator pod. Across the garage, Valtteri Bottas’ W12 was fitted with the higher downforce twin pillar arrangement.

This is not unusual behaviour by Mercedes this season either, as the team opted for different solutions as recently as the Portuguese Grand Prix, in order to boost its chances of beating Red Bull.

The lower downforce wing clearly gave Hamilton the straightline boost required, but conversely it should have put him at a disadvantage to Bottas through the middle sector.

However, the Finn continued to struggle with his W12, finding it unresponsive in terms of generating the right type of tyre temperatures.

The battle of the rear wing specs was also going on over at Ferrari too, as it started off its weekend with a spoon-shaped medium downforce wing on the car, before switching to the more traditional shaped mainplane design for FP3, qualifying and the race.

 

Photo by: Giorgio Piola

Ferrari’s change of heart allowed Charles Leclerc to grab another pole position, but the Monegasque driver slipped down the order come race day as the pack shuffled back into a more familiar pattern.

Unlike Red Bull, the switch to a lower downforce arrangement didn’t result in the deletion of the serrated upper rear cut-out, the upwash strikes or any changes to the hanging strakes. This means it is still keen to rework the vortex created at the wing tip.

Aston Martin had a couple of small detail changes available at the Azerbaijan Grand Prix which once again made their way on to Lance Stroll’s car ahead of Vettel’s.

These changes concern the area around the cockpit, with the halo fairing’s boomerang replaced by a pair of fins on either side of the safety structure that hope to position the airflow more effectively.

 

Photo by: Giorgio Piola

Meanwhile, in a similar fashion to what we’ve already seen from Mercedes, the wing mirror mounts had a serrated finish added to their surface in order to create a series of smaller vortices that also improved flow downstream.

Williams introduced a new bargeboard cluster in Azerbaijan. But with only enough parts to furnish one driver with the update, it was George Russell’s FW43B that carried them throughout the weekend.

The main design change is reminiscent of one that was made by McLaren toward the end of last season, with two C-shaped wings framing the main vertical bargeboard element and the upper boomerang.

Williams FW43B bargeboard detail

Williams FW43B bargeboard detail

Photo by: Giorgio Piola

shares
comments

Related video

The human cost to replacing Formula 1's cancelled rounds
Previous article

The human cost to replacing Formula 1's cancelled rounds

Next article

Bottas: Slump in form in Baku is "weird"

Bottas: Slump in form in Baku is "weird"
How a bad car creates the ultimate engineering challenge Plus

How a bad car creates the ultimate engineering challenge

While creating a car that is woefully off the pace is a nightmare scenario for any team, it inadvertently generates the test any engineering department would relish: to turn it into a winner. As Mercedes takes on that challenge in Formula 1 this season, McLaren’s former head of vehicle engineering reveals how the team pulled of the feat in 2009 with Lewis Hamilton

Formula 1
Aug 15, 2022
The under-fire F1 driver fighting for his future Plus

The under-fire F1 driver fighting for his future

Personable, articulate 
and devoid of the usual
 racing driver airs and graces,
 Nicholas Latifi is the last Formula 1 driver you’d expect to receive death threats, but such was the toxic legacy of his part in last year’s explosive season finale. And now, as ALEX KALINAUCKAS explains, he faces a battle to keep his place on the F1 grid…

Formula 1
Aug 13, 2022
The strange tyre travails faced by F1’s past heroes Plus

The strange tyre travails faced by F1’s past heroes

Modern grand prix drivers like to think the tyres they work with are unusually difficult and temperamental. But, says  MAURICE HAMILTON, their predecessors faced many of the same challenges – and some even stranger…

Formula 1
Aug 12, 2022
The returning fan car revolution that could suit F1 Plus

The returning fan car revolution that could suit F1

Gordon Murray's Brabham BT46B 'fan car' was Formula 1 engineering at perhaps its most outlandish. Now fan technology has been successfully utilised on the McMurtry Speirling at the Goodwood Festival of Speed, could it be adopted by grand prix racing once again?

Formula 1
Aug 11, 2022
Hamilton's first experience of turning silver into gold Plus

Hamilton's first experience of turning silver into gold

The seven-time Formula 1 world champion has been lumbered with a duff car before the 2022 Mercedes. Back in 2009, McLaren’s alchemists transformed the disastrous MP4-24 into a winning car with Lewis Hamilton at the wheel. And now it’s happening again at his current team, but can the rate of progress be matched this year?

Formula 1
Aug 11, 2022
Why few could blame Leclerc for following the example of Hamilton’s exit bombshell Plus

Why few could blame Leclerc for following the example of Hamilton’s exit bombshell

OPINION: Ferrari's numerous strategy blunders, as well as some of his own mistakes, have cost Charles Leclerc dearly in the 2022 Formula 1 title battle in the first half of the season. Though he is locked into a deal with Ferrari, few could blame Leclerc if he ultimately wanted to look elsewhere - just as Lewis Hamilton did with McLaren 10 years prior

Formula 1
Aug 9, 2022
The other McLaren exile hoping to follow Perez's path to a top F1 seat Plus

The other McLaren exile hoping to follow Perez's path to a top F1 seat

After being ditched by McLaren earlier in his F1 career Sergio Perez fought his way back into a seat with a leading team. BEN EDWARDS thinks the same could be happening to another member of the current grid

Formula 1
Aug 8, 2022
How studying Schumacher helped make Coulthard a McLaren F1 mainstay Plus

How studying Schumacher helped make Coulthard a McLaren F1 mainstay

Winner of 13 grands prix including Monaco and survivor of a life-changing plane crash, David Coulthard could be forgiven for having eased into a quiet retirement – but, as MARK GALLAGHER explains, in fact he’s busier than ever, running an award-winning media company and championing diversity in motor racing. Not bad for someone who, by his own admission, wasn’t quite the fastest driver of his generation…

Formula 1
Aug 7, 2022