Analysis: British Grand Prix Pirelli tyre failure causes

A perfect storm of kerb design, track layout, internal shockwaves and low pressures is likely to have caused the British Grand Prix tyre dramas, according to leading Formula 1 engineers

Analysis: British Grand Prix Pirelli tyre failure causes

A perfect storm of kerb design, track layout, internal shockwaves and low pressures is likely to have caused the British Grand Prix tyre dramas, according to leading Formula 1 engineers.

As Pirelli continues analysis of the remains of the tyre blow-outs at its Milan headquarters, preliminary investigations have pointed towards a combination of factors being to blame.

Much of the focus during the race was on the kerb layout at Silverstone; with drivers being advised to stay clear of them during the race once it emerged that damage was being done to the tyres.

Following feedback from drivers and a first look at the tyres, a closer inspection of the kerbs after the race indicated that there were two areas of the track that were of particular concern.

The first was an area inside the kerb at the Aintree kink (pictured right) that drivers appeared to be short-cutting at times with their inside left wheels to get a better entry onto the Wellington straight.

The serrated surface there is likely to have put increased strain on the inside edge of the left rear tyre, especially with tyre pressures being run as low as possible for performance reasons.

Running pressures low is good for durability, but it means the contact patch of the tyre moves towards the inside shoulder - the very area that was being punished by the kerbs.

As Red Bull technical chief Adrian Newey said: "The tyre failures appeared to have been from the inside shoulder of the rear tyre. By raising the pressure then you move the contact pressure [patch] more to the centre of the tyre and less onto the edge."

TYRE SHOCKWAVES

Allied to potential cuts being caused by running across the kerbs - as drivers were also doing at The Loop - the Aintree shortcut may also have set off what one engineer suggested was a 'shockwave' inside the tyre.

This shockwave is something that can be exacerbated with the kind of steel belt design that has been introduced for this year, which is why the kerb factors were not a problem in 2012 when Pirelli's tyres featured a Kevlar belt.

With the steel-belt tyres running around 10-degrees centigrade hotter than last year's Kevlar version, any temperature increase caused by the shockwaves will have put the rubber closer to the danger zone.

The other area of the track that is being singled out as a factor is the kerb on the exit of Becketts where drivers prepare for the left hander at Chapel curve onto Hangar straight.

Behind the red and white kerbs on the exit is an area of old and now rough concrete blocks (pictured) - exactly where some drivers had been placing their left rear tyre.

This will have likely put tremendous forces on to the inside shoulder of the tyre which, allied to the internal shockwaves caused by the rough area, helped trigger the failures that occurred on the Hangar straight.

Pirelli's forensic investigations are expected to deliver a definitive answer on the causes of the problem in the next 48 hours.

If the combination of kerb design, tyre specification and pressures is proven as the cause, then it will only increase the need for Pirelli to take action prior to the next race in Germany where similar factors could also come into play.

shares
comments
Ferrari, Lotus, Force India ready to relent over Pirelli tyre fix

Previous article

Ferrari, Lotus, Force India ready to relent over Pirelli tyre fix

Next article

Lewis Hamilton now hopeful on Formula 1 title chances

Lewis Hamilton now hopeful on Formula 1 title chances
Load comments
French Grand Prix Driver Ratings Plus

French Grand Prix Driver Ratings

The French GP was a weekend decided by tiny margins both at the front of the field, as Red Bull inflicted a comeback defeat on Mercedes, and in the battle for the minor points places. That's reflected in our driver ratings, where several drivers came close to a maximum score

How Red Bull took French GP "payback" on a day of Mercedes mistakes Plus

How Red Bull took French GP "payback" on a day of Mercedes mistakes

The French GP has been a stronghold for Mercedes since Paul Ricard's return to the calendar in 2018. But that all changed on Sunday, as a clever two-stop strategy guided Red Bull's Max Verstappen to make a race-winning pass on the penultimate lap - for once leaving Mercedes to experience the pain of late defeat it has so often inflicted on Red Bull

The new age of sponsorship facilitated by F1’s relevancy push Plus

The new age of sponsorship facilitated by F1’s relevancy push

The age of the high-profile title sponsor is over, says JONATHAN NOBLE, but Formula 1’s commitment to technological innovation is attracting high-tech partners

Formula 1
Jun 20, 2021
How Britain’s lost Ferrari star epitomised a bygone F1 era Plus

How Britain’s lost Ferrari star epitomised a bygone F1 era

The 1956 Italian Grand Prix was over for Juan Manuel Fangio, along with his hopes of winning the world championship – until his Ferrari team-mate (and title rival) voluntarily surrendered his own car so Fangio could continue. NIGEL ROEBUCK recalls Peter Collins, a remarkable sportsman

Formula 1
Jun 19, 2021
The 'surprise' Mercedes time that puts F1's victory fight back on a knife-edge in France Plus

The 'surprise' Mercedes time that puts F1's victory fight back on a knife-edge in France

Red Bull led the way after the first two practice sessions for the 2021 French Grand Prix, but only just ahead of Mercedes. There was all the usual practice skulduggery complicating the performance picture, but one aspect seen at the world champion squad gave it a ‘surprise’ lift, as it looks to leave its street-circuit struggles firmly in the past

Formula 1
Jun 18, 2021
How Ferrari got its F1 recovery plan working Plus

How Ferrari got its F1 recovery plan working

After its worst campaign in 40 years, the famous Italian team had to bounce back in 2021 – and it appears to be delivering. Although it concedes the pole positions in Monaco and Baku paint a somewhat misleading picture of its competitiveness, the team is heading into the 2022 rules revamp on much stronger footing to go for wins again

Formula 1
Jun 18, 2021
The joy that exposes F1’s key weakness Plus

The joy that exposes F1’s key weakness

Long-awaited wins for ex-Formula 1 drivers Marcus Ericsson and Kevin Magnussen in IndyCar and IMSA last weekend gave F1 a reminder of what it is missing. But with the new rules aimed at levelling the playing field, there’s renewed optimism that more drivers can have a rewarding result when their day of days comes

Formula 1
Jun 17, 2021
The figures Red Bull and Mercedes can't afford to see again in F1 2021 Plus

The figures Red Bull and Mercedes can't afford to see again in F1 2021

OPINION: An interloper squad got amongst the title contenders during Formula 1’s street-circuit mini-break, where Red Bull left with the points lead in both championships. But, as the campaign heads back to purpose-built venues once again, how the drivers of the two top teams compare in one crucial area will be a major factor in deciding which squad stays in or retakes the top spot

Formula 1
Jun 16, 2021